Product ID:70 92, 70-092 BREAKTHRU GLS-LIGHT GRAY
MSDS Date:01/01/1992
FSC:8010
NIIN:00N030781
MSDS Number: BNQRL

VANEX COLOR INC

1700 S SHAWNEE ST
MT VERNON, IL 62864
US

Emergency Phone: 618-244-1416

Info Phone: 800-851-7390

Preparer: PATRICE BLACKMON

Cage: HO921

VANEX COLOR INC

MT VERNON, IL 62864 US

Telephone: 800-851-7390

Cage: HO921

ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER). VP

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 8%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

0.0

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 2%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPS OF THIS MATL MAY IRRITATE
NOSE, THROAT & RESP PASSAGES. HIGHER CONC CAN INDUCE HDCH, DIZZ,
NAUS, DROWS & SHORTNESS OF BREATH. SKIN: NO IRRIT IS LIKELY TO
DEVELOP FOLLOWING SHORT CONTACT PE RIODS W/HUMAN SKIN. PRLNGD/RPTD
EXPOS CAN LEAD TO REDNESS, SWELLING & NECROSIS. EYE: THIS MATL CAN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INDUCE PAIN & MODERATE IRRIT. SKIN
ABSORP: ADVERSE SYSTEMIC EFTS CAN DEVELOP FOLLOWING RPTD/PRLNGD
CONT W/ HUMAN SKIN. INGEST: A SINGLE DOSE OF THIS PROD IS
MODERATELY TOXIC BY INGEST. ACUTE & CHRONIC: INHAL OF HIGH CONC OF
VAPORCAN INDUCE ANEMIA, LIVER AND KIDNEY INJURY & CLOUDING OF THE
CORNEA. (SUPP DATA)
Medical Cond Aggravated by Exposure:LUNG DISEASES.

First Aid:SKIN:REMOVE CONTAM CLTHG & FOOTWEAR. WASH MATL OFF W/SOAP &
WATER. IF REDNESS/ITCHING/BURNING SENSATION DEV, CALL MD. WASH
CONTAM CLTHG & DECONTAM FOOTWEAR BEFORE REUSE. EYES:IMMED FLUSH W/
WATER FOR AT LEAST 15 MIN & HAVE EYES EXAMINED & TREATED BY MED
PERS. INGEST:GIVE 1-2 GLASSES OF WATER TO DRINK. INDUCE VOMIT.
REFER VICTIM TO MED PERS. INHAL:REMOVE VICTIM TO FRESH AIR. IF
COUGH/ (SUPP DATA)

Flash Point Method:CC
Flash Point:210F,99C
Lower Limits:0.5%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS ARE
KNOWN FOR THIS PROD. AS TYPICAL OF CLOSED CONTAINERS CONTAINING
LIQUID, THEY MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:DIKE AND CONTAIN SPILL WITH INERT MATERIALS
(SAND, CLAY, EARTH, ETC). TRANSFER THE LIQUID TO CONTAINERS FOR
RECOVERY OR DISPOSAL. KEEP SPILL OUT OF SEWERS AND OPEN BODIES OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP FROM FREEZING. KEEP AWAY FROM
HEAT & OPEN FLAME. AVOID BREATHING VAPOR. AVOID CONT W/EYES, SKIN &
CLOTHING. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:USE WITH VENT ADEQ TO MAINTAIN VAPOR CONC BELOW THE
TLV. CONTAINERS OF PROD MAY BE HAZ WHEN EMPTIED-ALL HAZ PREC MUST
BE OBSERVED.

Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE A NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILATION TO CONTROL
AIRBORNE LEVELS BELOW THE EXPOSURE GUIDELINES.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND SHOES.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY. WASH
SKIN AREA WITH SOAP & WATER. LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP: ANIMAL STUDIES CLEARLY DEMONSTRATED DOSE-RELATED
ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD, KIDNEYS & LIVER,
ASSOC W/THE ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE)
(EXTRACTE D FROM DHHS (NIOSH) PUB NO. 90-118) FIRST AID PROC:
OTHER RESPIRATORY SYSTEMS DEVELOP, CALL MD.

HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.1 (H2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:COMBUSTION PRODUCTS: CO2, CO.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.